Critical flux in cross-flow ultrafiltration of protein solutions

The effect of solute size relative to membrane pore size on the critical flux during the ultrafiltration of protein solutions was investigated using the constant pressure method. Hydrophilic regenerated cellulose membranes with a cut-off of 10, 30 and 100 kg mol!1, model proteins and skimmed milk solutions were used. The critical flux mainly increased with the pore size of the ultrafiltration membrane. The lowest critical fluxes, 40–50 L m!2 h!1, were obtained with the retentive 10 kg mol!1 cut-off membrane. This membrane had a very low permeability and, thus, the critical fluxes were achieved at high transmembrane pressures (TMP): 1.7–2.3 bar. With the 100 kg mol!1 cut-off membrane critical fluxes were obtained at 0.2 bar TMP, which were around 100 L m!2 h!1, slightly declining with increasing protein molar mass. In skimmed milk experiments the permeate flux decreased when the protein molecules were enzymatically split to peptides. A critical flux for skimmed milk solution could not be found unless the protein concentration was diluted to 0.3-w% or lower. The results with model proteins were then compared to those obtained with skimmed milk resulting in $-lactoglobulin being the worst foulant.

The effect of solute size relative to membrane pore size on critical flux during the UF of proteins was investigated with three hydrophilic membranes with 10, 30 and 100 kg mol!1 cut-off values using the constant pressure method. Not such a clear effect was found as with hard particles, as different proteins behave differently in filtration. Nevertheless, in this study the